Mike "Wuzzy121". Rest in peace, brother

Go Back   Tacoma World Forums > Tacoma Discussion > 1st Gen. Tacomas

Notices

Serpentine Belt/ Supercharger Belt Replacement

Reply
 
Thread Tools Search this Thread
Old 01-13-2009, 07:08 PM   #1
Coma17 [OP] Coma17 is offline
Junior Member
Coma17 is on a distinguished road
Joined: Jul 2008, #8157
Location: Mesa, Az
Gender: Male
Posts: 4
Coma17's Tacoma Gallery
Serpentine Belt/ Supercharger Belt Replacement

Here is the belt info for an (my) 2003 Supercharged PreRunner.

A/C Belt - Duralast(from Autozone) - 342K4 4PK0870
P/S Belt - Duralast(from Autozone) - 420K4 4PK1065
S/C Belt - Toyota(from Toyota Dealer) -PTR30-35040

I recently noticed that my supercharger belt was cracking. So, of course I searched TW for any hints, tips, or info on belt numbers and how to's. I found nothing. I ended up just going to Autozone and getting the Power steering belt and the A/C belt and replacing them as well because they had to come off to replace the Supercharger belt. I looked around and found that the Power Steering pump had a tension bolt, so I loosened the mount bolt that locks the tensioner in place, then the tensioner. The A/C had a pulley, which is located below the Power Steering, that also had a tension bolt. I had to loosen the pulley's center spindle bolt to release the tensioner to be able to relieve the tension. Both belts were still a little tough to get off and required a little finess, the help of a flat head screwdriver took care of that.
Once the A/C and Power Steering belts were off, I used a 3/8" drive breaker bar to release the S/C belt. Then, with a little bit of force, slid the S/C belt behind the tensioner pulley, and manuevered it around the fan and it was out.
Reverse the process to install!
  Reply With Quote
Old 03-22-2012, 03:52 PM   #2
Junior Member
MaxN1 is on a distinguished road
Navy:
Joined: Oct 2010, #44181
Location: Virginia Beach, VA
Gender: Male
Posts: 3
MaxN1's Tacoma Gallery
Part # of the S/C serpentine belt from the dealer still checks out; $30. Apparently its hard for them to look up, so that could help having it for them.
  Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search

Similar Threads
Thread Thread Starter Forum Replies Last Post
Serpentine Belt Replacement? eyball 2nd Gen. Tacomas 43 12-15-2014 07:06 AM
serpentine belt replacement dustinclm Technical Chat 1 02-09-2011 10:02 AM
2010 4.0 Supercharger Serpentine Belt novakills Performance and Tuning 5 10-18-2010 07:06 AM
Serpentine Belt Replacement DGXR 4 Cylinder 3 02-03-2010 01:31 PM
V-belt/ serpentine replacement LBtaco 2nd Gen. Tacomas 5 11-20-2009 08:21 AM


Copyright © 2014 Tacoma Forum. Tacoma World is not owned by, or affiliated with Toyota Motor Corporation.