Mike "Wuzzy121". Rest in peace, brother

Go Back   Tacoma World Forums > Tacoma Garage > 5 Lug

Notices

High idle on 2002 Taco 5 lug 2.4L

Reply
 
Thread Tools Search this Thread
Old 08-07-2013, 07:40 PM   #1
Todduscg98 [OP] Todduscg98 is offline
Junior Member
Todduscg98 is on a distinguished road
Coast Guard: Chief Boatswains Mate
Name: Todd
Joined: Aug 2013, #110002
Location: Galveston
Gender: Male
Posts: 2
Todduscg98's Tacoma Gallery
High idle on 2002 Taco 5 lug 2.4L

Hello everyone. I am new to Tacomaworld and wanted to thank everyone and the awesome information you can get here. I had the high idle problem when my engine warmed up. I don't have an RPM gauge but man you could hear it idling high. I am guessing over 1500 rpm's. After researching through the forums I decided it must be the Idle Air Control valve (IAC). When I took off the throttle body I noticed a lot of carbon build up. I took off the IAC and sure enough it had some serious build up and the valve didn't turn. So I took some brake cleaner a scribe and some q-tips and cleaned it out. After a thorough cleaning it turned with ease. Put it all back together and bam. Just like that it was fixed. It runs better than when I got it. Again you guys saved me lots of money. Thank you so much. If anyone needs any info on this just ask. It took me about 1.5 hours to complete not bad at all. Only thing is be very careful of the brass screws. I had to replace mine. I put hex heads on as a replacement.

Now my question I how to prevent the build up in my throttle body. Below is a pic of my throttle body. I don't want to have to do this again.
Attached Thumbnails
High idle on 2002 Taco 5 lug 2.4L-image.jpg  
  Reply With Quote
Old 08-08-2013, 08:43 AM   #2
Senior Member
MowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shedMowTaco is one of the sharper tools in the shed
 
MowTaco's Avatar
Name: Matt
Joined: Sep 2009, #22530
Location: Kansas/Iowa/South Dakota
Age: 20
Gender: Male
Posts: 3,694
MowTaco's Tacoma Gallery
You could try an oil catch can like the one in this group buy:

http://www.tacomaworld.com/forum/gro...group-buy.html

I guess it's closed but you could still find something similar. It filters out the oil that comes out of the PCV and only allows air back into the intake. It isn't much oil that comes through, but as the engine wears it gets worse as the rings get a little loser and allow more oil to blow through. This oil "mist" gets recirculated back into your intake (theoretically it's just air venting from the crankcase with temperature changes but a little oil comes with it) and burned in the engine. The oil coats the intake system and then allows any spec of dirt to cling to it and will build up over time.
  Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search

Similar Threads
Thread Thread Starter Forum Replies Last Post
High Idle 2002 3.4 L Tacoma lostinacloud New Members 1 06-26-2013 09:51 AM
idle too high 2002 Toyota Tacoma 2.7L Enrique 1st Gen. Tacomas 0 02-13-2013 12:05 PM
1jz swap on 2002 5 lug taco any advice or comments? tacowhore Street Trucks 38 08-22-2012 05:36 AM
fixed high idle now ac wont work at idle KenC 1st Gen. Tacomas 3 07-06-2012 03:47 PM
2002 Taco 2.4 liter inconsistent rough idle ToyotaCoupe 4 Cylinder 2 12-29-2010 02:39 PM


Copyright © 2014 Tacoma Forum. Tacoma World is not owned by, or affiliated with Toyota Motor Corporation.