TSB: Exhaust System - Ticking Noise Between 2,000-2,500 RPM

Found this on all data i know ive seen some posts about this concern on these forums thought id post the TSB i found

ENGINE
EG021-06

Title:
EXHAUST TICKING NOISE

Models:
'05 - '06 Tacoma

April 7, 2006

Introduction

Some customers may experience a ticking or tapping-type noise from the engine area at 2000 - 2500 rpm during acceleration that is most noticeable after a cold soak. New exhaust manifolds have been developed to minimize this condition.

Applicable Vehicles

^ 2005 - 2006 model year Tacoma vehicles produced BEFORE the Production Change Effective VIN shown below.


Production Change Information



Parts Information

Repair Procedure

Replace both LH and RH exhaust manifolds.

Refer to the Technical Information System (TIS), 2005 or 2006 model year Tacoma Repair Manual: 1GR-FE Engine Mechanical: Partial Engine Assy: Replacement.


Warranty Information

Applicable Warranty*:
The Remove & Reinstall (R & R) of the Exhaust Manifold (P/N 17140-0P010 and 17150-0P010) due to the attached Catalytic Converter, is covered under the Toyota Federal Emissions Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle's in-service date.

* Warranty application is limited to correction of a problem based upon a customer's specific complaint.

 

Your the man. This is the type of information that is VERY helpful. Anything about a minor surge feeling when your at a complete stop?

 

Ill check, btw i see the links are dead ill have to upload them to a photobucket account or some thing

just checked didnt see any thing

 

Thanks man. Your the eye in the sky when it comes to watching for this stuff. I know, a lot of responsibility but we have faith in you. Thanks again